针对两端刚性支撑的Jeffcott转子,建立了一个三自由度、弯扭耦合的Filippov碰摩转子系统。通过对比有无考虑扭振的碰摩转子的振幅和激励及响应相位差随转动角速度变化的分岔图及转子的时间历程图、相图、Poincaré截面图,数值分析了弯扭耦合的Filippov碰摩转子系统的碰摩响应相位特征和非光滑动力学行为。分析表明:对于弯扭耦合的Filippov碰摩转子系统,振动响应具有确定的相位特征;两类方程分叉图的变化过程基本相同;扭转现象明显;在一定参数下,系统会出现stick-slip现象。 A three-degree-of-freedom lateral-torsional coupled Filippov differential system for a Jeffcott rotor supported rigidly is established. Comparing the lateral-torsional coupled rub-impact rotor and the lateral rub-impact rotor through bifurcation diagrams of amplitude and the phase difference, time trajectories, phase portraits, Poincaré maps, time-history diagram, the phase characteristic and the non-smooth dynamic behavior of the Filippov rub-impact system are analyzed numerically. It is shown that the rub-impact response has the definite phase characteristic; the two models have a similar bifurcation process in their bifurcation figures; the torsional vibration is obvious, and the stick-slip phenomena will happen in this system in a certain parameter.
参考文献 (References)ReferencesYu, J.J., Goldman, D.E., Bently, D.E. and Muzynska, A. (2002) Rotor/seal experimental and analytical study on full annular. Journal of Engineering for Gas Turbines and Power, 124, 340-350.Chu, F. and Zhang, Z. (1998) Bifur-cation and chaos in a rub-impact Jeffcott rotor system. Journal of Sound and Vibration, 210, 1-18.Jiang, J. and Ulbrich, H. (2005) Stability analysis of sliding whirl in a nonlinear Jeffcott rotor with cross-coupling stiffness coeffi-cients. Nonlinear Dynamics, 127, 163-178.Zhang, W.M. and Meng, G. (2006) Stability, bifurcation and chaos of a high-speed rub-impact rotor system in MEMS. Sensors and Actuators A, 127, 163-178.Karpenkoa, E.V., Wiercigroch, M., Pavlovskaia, E.E. and Neilsona, R.D. (2006) Experimental verification of Jeffcott rotor model with preloaded snubber ring. Journal of Sound and Vibration, 298, 907-917.Edwards, S., Lees, A.W. and Friswell, M.I. (1999) The influence of torsion on rotor/stator contact in rotating machinery. Journal of Sound and Vibration, 225, 767-778.何成兵, 顾煜炯, 李猛 (2006) Jeffcott转子碰摩的弯扭耦合振动特性分析. 振动与冲击, 2, 59-63.张跟胜, 丁千, 陈予恕 (2009) 轴向摩擦双盘转子的振动分析. 机械强度, 5, 712-718.Patel, T.H. and Darpe, A.K. (2009) Coupled beading-torsional vibration analysis of rotor with rub and crack. Journal of Sound and Vibration, 326, 740-752.Wang, S.M., Lu, Q.S., Wang, Q. and Xu, P. (2006) Reducing the amplitude of vibration at resonances by phase modulation. Journal of Sound and Vibration, 290, 410-424.Wang, S.M., Xu, J.Q. and Wang, Q. (2010) The mechanism of stiffness increase phenomenon of a rubbing disk. Journal of Acta Mechanica Sinica, 26, 441-448.徐洁琼, 王士敏, 王琪 (2010) 碰摩转子刚度增加现象的相位特征. 振动与冲击, 6, 114-148.