本文研制了一套笔式结构的气味参考样品,可定量散发β-苯乙醇、甲基环戊酮、异戊酸、γ-十一碳酸内酯和β-甲基吲哚等五种标准气味物质。通过小型散发罩法对研制的气味参考样品进行测试,在设定条件下,β-苯乙醇、甲基环戊酮、γ-十一碳酸内酯、异戊酸和β-甲基吲哚的散发速率分别为242.84 μg/min、254.47 μg/min、226.34 μg/min、242.27 μg/min、161.86 μg/min;通过嗅觉测试对其气味强度评价,五组气味强度成对样本t检验中p值均大于0.05,气味强度无显著差异;经过50次嗅辨实验后,5支气味参考样品的散发速率相对标准偏差均小于5.0%。结果表明,研制的气味参考样品具有操作简单、散发稳定、可重复使用等特点,可用于嗅辨员的筛选。<br>A set of reference material with a pen-like structure was developed in this paper, which can quantitatively emit five standard odorants, including β-phenylethyl alcohol, methyl-cyclopentanone, isovaleic acid, γ-undecalactone and skatole. The odor reference material and its national standard test paper were tested by the emission test cell method. Under the condition of 23˚C ± 2˚C, 50% ± 10% RH, ventilation volume 0.52 L/min, the emission rates of five odor reference materials, β-phenylethyl alcohol, methyl-cyclopentanone, γ-undecalactone, isovaleic acid and skatole, were 242.84 μg/min, 254.47 μg/min, 226.34 μg/min, 242.27 μg/min, 161.86 μg/min respectively. The odor intensity of these five odor reference materials were evaluated by olfactory test. The p-values in the paired-samples T test of the odor intensity of the five groups were all greater than 0.05, and there was no significant difference in the odor intensity. The relative standard deviations of the emission rates of the five odor reference materials were all less than 5.0% after 50 olfactory experiments. The results show that the developed odor reference material has characteristics of convenient operation, stable emission rate, and reusability, which can be used for the screening panelists in the future.
本文研制了一套笔式结构的气味参考样品,可定量散发β-苯乙醇、甲基环戊酮、异戊酸、γ-十一碳酸内酯和β-甲基吲哚等五种标准气味物质。通过小型散发罩法对研制的气味参考样品进行测试,在设定条件下,β-苯乙醇、甲基环戊酮、γ-十一碳酸内酯、异戊酸和β-甲基吲哚的散发速率分别为242.84 μg/min、254.47 μg/min、226.34 μg/min、242.27 μg/min、161.86 μg/min;通过嗅觉测试对其气味强度评价,五组气味强度成对样本t检验中p值均大于0.05,气味强度无显著差异;经过50次嗅辨实验后,5支气味参考样品的散发速率相对标准偏差均小于5.0%。结果表明,研制的气味参考样品具有操作简单、散发稳定、可重复使用等特点,可用于嗅辨员的筛选。
参考样品,散发速率,气味强度,嗅辨员筛选
Yiting Jia, Ning Liu, Weijie Liu, Yanni Zhang, Jinhua Liu, Jingjing Zhang, Peng Sun, Peng Zhao, Zhanwu Ning*
Institute of Urban Safety and Environmental Science, Beijing Academy of Science and Technology, Beijing
Received: Mar. 12th, 2022; accepted: Apr. 14th, 2022; published: Apr. 21st, 2022
A set of reference material with a pen-like structure was developed in this paper, which can quantitatively emit five standard odorants, including β-phenylethyl alcohol, methyl-cyclopentanone, isovaleic acid, γ-undecalactone and skatole. The odor reference material and its national standard test paper were tested by the emission test cell method. Under the condition of 23˚C ± 2˚C, 50% ± 10% RH, ventilation volume 0.52 L/min, the emission rates of five odor reference materials, β-phenylethyl alcohol, methyl-cyclopentanone, γ-undecalactone, isovaleic acid and skatole, were 242.84 μg/min, 254.47 μg/min, 226.34 μg/min, 242.27 μg/min, 161.86 μg/min respectively. The odor intensity of these five odor reference materials were evaluated by olfactory test. The p-values in the paired-samples T test of the odor intensity of the five groups were all greater than 0.05, and there was no significant difference in the odor intensity. The relative standard deviations of the emission rates of the five odor reference materials were all less than 5.0% after 50 olfactory experiments. The results show that the developed odor reference material has characteristics of convenient operation, stable emission rate, and reusability, which can be used for the screening panelists in the future.
Keywords:Reference Material, Emission Rate, Odor Intensity, Screening Panelists
Copyright © 2022 by author(s) and Hans Publishers Inc.
This work is licensed under the Creative Commons Attribution International License (CC BY 4.0).
http://creativecommons.org/licenses/by/4.0/
随着工业的迅猛发展,全球气味污染问题日益严重,世界各国对气味污染都给予了高度重视,气味污染评价的技术得到快速发展 [
目前,试纸法是较多国家筛选嗅辨员的基本方法。ISO16000-28 [
本研究研制了一套笔式结构的气味参考样品,可定量散发β-苯乙醇、甲基环戊酮、异戊酸、γ-十一碳酸内酯和β-甲基吲哚等五种标准气味物质,通过小型散发罩法和气味强度嗅觉测试对气味参考样品散发量、气味强度及散发稳定性进行性能测试。
笔式结构参考样品气味散发的方式是基于差动毛细效应 [
J = − D ⋅ d C d x (1)
式中:
J——扩散通量(kg/m2·s);
D——扩散系数(m2/s);
C——扩散物质的体积浓度(kg/m3);
dC/dx——浓度梯度。
图1. 气味参考样品散发及嗅辨示意图
本研究的测试系统如图2所示,包括气体处理单元、散发单元和测试单元,测试舱内壁为经过抛光处理的不锈钢材质,具有低吸附、无散发特点。通过湿度控制系统通入相对湿度50% ± 10%的洁净空气与另一路干燥空气均匀混合后进入测试舱,温度控制系统控制温度保持在23℃ ± 2℃,检查测试舱密闭性并调节空气流速,待系统稳定后将制备好的气味参考样品拔下笔帽后放入小型散发罩中,笔头中的气味物质在笔头与散发罩内空气的浓度差作用下由笔头向散发罩内空气传质,用GC-PID测试散发罩内气味物质的浓度。假设小型散发罩满足密闭性良好,散发罩中空气混合均匀,根据质量守恒定律 [
V d C a d t = m − Q C a (2)
式中:
V——小型散发罩的体积(L);
Ca——小型散发罩内气味物质的浓度(μg/L);
t——散发时间(min);
m——笔头的散发速率(μg/min);
Q——小型散发罩通风量(L/min)。
装置经过一定时间的散发后达到稳定,散发罩内气味物质的浓度随时间的变化可忽略,此时笔头的散发速率可简化为:
m ≈ QC a (3)
图2. 测试系统示意图
实验试剂:2-苯乙醇、异戊酸、3-甲基环戊酮、3-甲基吲哚、γ-十一烷酸内酯、液体石蜡,纯度均为99%。
实验设备:小型散发罩(依据标准自制 [
实验条件:温度23℃ ± 2℃,湿度50% ± 10%,通风量0.52 L/min。
以液体石蜡作为稀释剂,分别对β-苯乙醇、甲基环戊酮、异戊酸、γ-十一碳酸内酯和β-甲基吲哚等五种溶液进行稀释,按照5种标准气味物质的不同气味特点及国标中对标准嗅液浓度的规定(见表1),配制稀释倍数为10,000到100,000的混合溶液各4 mL,垂直芯吸入海绵芯体,笔头插入笔芯中,组装并分别编号,静置24小时。稀释倍数及编号如表2所示。
通过GB/T32443-2015中小型散发罩法 [
序号 | 标准嗅液 | 浓度(ω/ω) | 气味类型 |
---|---|---|---|
1 | β-苯乙醇 | 10−4.0 | 花香 |
2 | 异戊酸 | 10−5.0 | 汗臭气味 |
3 | 甲基环戊酮 | 10−4.5 | 甜锅巴气味 |
4 | γ-十一碳酸内酯 | 10−4.5 | 成熟水果香 |
5 | β-甲基吲哚 | 10−5.0 | 粪臭气味 |
表1. 五种标准嗅液的浓度和气味类型
稀释 倍数 编号 标准 气味物质 | 10,000 | 20,000 | 30,000 | 40,000 | 60,000 | 80,000 | 100,000 |
---|---|---|---|---|---|---|---|
甲基环戊酮 | S10000 | S20000 | S30000 | —— | —— | —— | —— |
β-苯乙醇 | S10000 | S20000 | S30000 | —— | —— | —— | —— |
γ-十一碳酸内酯 | S10000 | S20000 | S30000 | —— | —— | —— | —— |
β-甲基吲哚 | —— | S20000 | —— | S40000 | S60000 | S80000 | S100000 |
异戊酸 | —— | S20000 | —— | S40000 | S60000 | S80000 | S100000 |
表2. 气味参考样品稀释倍数及编号
通过阶段法 [
等级级别 | 状态描述 |
---|---|
0级 | 无气味 |
1级 | 非常弱 |
2级 | 弱 |
3级 | 明显 |
4级 | 强 |
5级 | 非常强 |
6级 | 极强,不能忍受 |
表3. 七阶段法气味强度等级表
分别对5支气味参考样品进行50次嗅辨实验,每10次嗅辨实验后进行一次散发量测试,按式(3)计算散发速率,检验气味参考样品的散发稳定性。
通过对气味参考样品及国标试纸的散发量比对,筛选与国标试纸具有相近散发浓度的气味参考样品,确定5种参考样品的稀释倍数。结果如图3所示,散发量随溶液稀释倍数的增大而减小,β-苯乙醇、甲基环戊酮、γ-十一碳酸内酯的S30000,异戊酸和β-甲基吲哚的S80000与国标试纸的散发量相近,散发速率分别为242.84 μg/min、254.47 μg/min、226.34 μg/min、242.27 μg/min、161.86 μg/min,故选择β-苯乙醇S30000、异戊酸S80000、甲基环戊酮S30000、β-甲基吲哚S80000、γ-十一碳酸内酯S30000等5支气味参考样品进行后续气味强度评价及稳定性测试。
图3. 气味参考样品与其国标试纸散发量对比
通过对气味参考样品和国标试纸的气味强度比对,验证二者强度等级的一致性。8名嗅辨员依次对β-苯乙醇S30000、异戊酸S80000、甲基环戊酮S30000、β-甲基吲哚S80000、γ-十一碳酸内酯S30000等5支气味参考样品及其国标试纸进行气味强度评价。表4为嗅辨员气味强度等级结果及成对样本t检验结果,结果显示,五组样本p值均大于0.05,表明5支气味参考样品与其国标试纸的气味强度无显著差异,具有一致性。
嗅辨小组 | 气味强度等级 | |||||||||
---|---|---|---|---|---|---|---|---|---|---|
甲基环戊酮 | β-苯乙醇 | γ-十一碳酸内酯 | β-甲基吲哚 | 异戊酸 | ||||||
国标 试纸 | 气味参考样品 | 国标 试纸 | 气味参考样品 | 国标 试纸 | 气味参考样品 | 国标 试纸 | 气味参考样品 | 国标 试纸 | 气味参考样品 | |
嗅辨员1 | 2 | 3 | 3 | 2 | 1 | 2 | 2 | 3 | 3 | 4 |
嗅辨员2 | 2 | 2 | 2 | 3 | 2 | 2 | 2 | 2 | 2 | 3 |
嗅辨员3 | 1 | 2 | 2 | 2 | 2 | 2 | 3 | 2 | 3 | 3 |
嗅辨员4 | 2 | 2 | 2 | 2 | 2 | 1 | 2 | 2 | 3 | 3 |
嗅辨员5 | 2 | 2 | 2 | 2 | 1 | 2 | 1 | 2 | 3 | 3 |
嗅辨员6 | 2 | 2 | 2 | 2 | 2 | 2 | 2 | 2 | 2 | 3 |
嗅辨员7 | 2 | 3 | 2 | 3 | 2 | 2 | 3 | 3 | 3 | 3 |
嗅辨员8 | 2 | 2 | 2 | 2 | 2 | 2 | 2 | 2 | 3 | 3 |
平均值 | 1.88 | 2.25 | 2.13 | 2.25 | 1.75 | 1.88 | 2.13 | 2.25 | 2.75 | 3.13 |
t值 | −2.05 | −0.55 | −0.55 | −0.55 | −2.05 | |||||
p值 | 0.08 | 0.60 | 0.60 | 0.60 | 0.08 |
表4. 8名嗅辨员嗅辨结果
根据散发量及气味强度测试结果,对β-苯乙醇S30000,异戊酸S80000,甲基环戊酮S30000,β-甲基吲哚S80000,γ-十一碳酸内酯S30000等5支气味参考样品进行50次嗅辨实验,检验气味参考样品的稳定性。结果如图4所示,每10次嗅辨实验后进行一次散发量测试,β-苯乙醇、甲基环戊酮、γ-十一碳酸内酯、异戊酸和β-甲基吲哚的平均散发速率分别为230.78 μg/min、244.40 μg/min、216.22 μg/min、228.80 μg/min、159.95 μg/min,相对标准偏差均小于5.0%,表明研制的气味参考样品散发稳定,可重复使用。
图4. 气味参考样品稳定性测试结果
本文研制出一套笔式结构的气味参考样品,可定量散发β-苯乙醇、甲基环戊酮、异戊酸、γ-十一碳酸内酯和β-甲基吲哚等五种标准气味物质。通过小型散发罩法对研制的气味参考样品进行测试,在23℃ ± 2℃、50% ± 10% RH、通风量0.52 L/min条件下,β-苯乙醇、甲基环戊酮、γ-十一碳酸内酯、异戊酸和β-甲基吲哚的散发速率分别为242.84 μg/min、254.47 μg/min、226.34 μg/min、242.27 μg/min、161.86 μg/min;通过嗅觉测试对其气味强度评价,五组气味强度成对样本t检验中p值均大于0.05,气味强度无显著差异;经过50次嗅辨实验后,5支气味参考样品的散发速率相对标准偏差均小于5.0%。结果表明,研制的气味参考样品具有开盖即用、方便快捷、散发稳定、可重复使用等特点,可用于嗅辨员的筛选。
贾依婷,刘 凝,刘未杰,张艳妮,刘锦华,张晶晶,孙 芃,赵 鹏,宁占武. 用于嗅辨员筛选的气味参考样品制备研究Development of Odor Reference Material for Screening Panelists[J]. 环境保护前沿, 2022, 12(02): 251-258. https://doi.org/10.12677/AEP.2022.122033